Journal of Applied Science and Engineering

Published by Tamkang University Press

1.30

Impact Factor

1.60

CiteScore

Azridjal Aziz This email address is being protected from spambots. You need JavaScript enabled to view it.1 and Akio Miyara2

1Department of Mechanical Engineering, Riau University, Kampus Bina Widya, Km 12,5, Sp. Baru, Panam, Pekanbaru, 28293, Indonesia
2Department of Mechanical Engineering, Saga University, 1 Honjomachi Saga-shi, 840-8502, Japan


 

Received: May 1, 2014
Accepted: January 12, 2015
Publication Date: March 1, 2015

Download Citation: ||https://doi.org/10.6180/jase.2015.18.1.05  


ABSTRACT


This study presents an experimental investigation of air-water mixture distribution (gas and liquid phase) in a distributor. The distributor with one inlet and two outlet tubes branch, upper part and lower part is used with the aim that flow through it can be distributed evenly, particularly in two phase flow. The flow distribution was observed by a high-speed video camera and volumetric flow rates of air and water were measured for each outlet branches, respectively. Inclination angle effect of the distributor and flow rate of air and water flow pattern were investigated. It was found that through distributor, evenly distribution will occurs by the superficial velocity gas and liquid in large quantity. Water tends to flow out at the bottom, and air tends to flow out at the top of tube branch because effect of gravity and different fluid density. The distribution of two-phase flow through distributors tend unevenly flow distribution on the decrease of the angle of distributor, from vertical position to horizontal position.


Keywords: Visualization, Two-Phase Flow, Distributor, Flow Pattern, Distribution


REFERENCES


  1. [1] Lee, J. K. and Lee, S. Y., “Distribution of Two-Phase Annular Flow at Header-Channel Junctions,” Experimental Thermal and Fluid Science, Vol. 28, No. 23, pp. 217222 (2004). doi: 10.1016/S0894-1777 (03)00042-6
  2. [2] Vist, S. and Pettersen, J., “Two-Phase Flow Distribution in Compact Heat Exchanger Manifolds,” Experimental Thermal and Fluid Science, Vol. 28, No. 23, pp. 209215 (2004). doi: 10.1016/S0894-1777 (03)00041-4
  3. [3] Marchitto, A., Devia, F., Fossa, M., Guglielmini, G. and Schenone, C., “Experiments on Two-Phase Flow Distribution Inside Parallel Channels of Compact Heat Exchangers,” International Journal of Multiphase Flow, Vol. 34, No. 2, pp. 128144 (2008). doi: 10.1016/j.ijmultiphaseflow.2007.08.005
  4. [4] Tae, S. J. and Cho, K., “Two-Phase Flow Distribution and Phase Separation through Both Horizontal and Vertical Branches,” KSME International Journal, Vol. 17, No. 8, pp. 12111218 (2003).
  5. [5] Wen, M. Y., Lee, C. H. and Tasi, J. C., “Improving Two-Phase Refrigerant Distribution in the Manifold of the Refrigeration System,” Applied Thermal Engineering, Vol. 28, No. 1718, pp. 21262135 (2008). doi: 10.1016/j.applthermaleng.2007.11.019
  6. [6] Kim, N. H. and Sin, T. R., “Two Phase Flow Distribution of Air-Water Annular Flow in Parallel Flow Heat Exchanger,” International Journal of Multiphase Flow, Vol. 32, No. 12, pp. 13401353 (2006). doi: 10.1016/ j.ijmultiphaseflow.2006.07.005
  7. [7] Aziz, A., Miyara, A. and Sugino, F., “Distribution of Two-Phase Flow in a Distributor,” Journal of Engineering Science and Technology, Vol. 7, No. 1, pp. 41 55 (2012).
  8. [8] Yoshioka, S., Kim, H. and Kazai, K., “Performance Evaluation and Optimization of a Refrigerant Distributor for Air Conditioner,” Journal of Thermal Science and Technology, Vol. 3, No. 1, pp. 6877 (2008). doi: 10.1299/jtst.3.68
  9. [9] Wong, T. N. and Yau, Y. K., “Flow Patterns in TwoPhase Air-Water Flow,” International Communications in Heat and Mass Transfer, Vol. 24, No. 1, pp. 111118 (1997). doi: 10.1016/S0735-1933(96)00110-8
  10. [10] Brennen, C. E., Fundamentals of Multiphase Flows, Cambridge University Press, UK, pp. 163183 (2005). doi: 10.1017/CBO9780511807169.010
  11. [11] Wambsganss, M. W., Jendrzejczyk, J. A. and France, D. M., “Two-Phase Flow Patterns and Transitions in a Small, Horizontal, Rectangular Channel,” International Journal of Multiphase Flow, Vol. 17, No. 3, pp. 327342 (1991). doi: 10.1016/0301-9322(91)90 003-L
  12. [12] Massoud, M., Engineering Thermo Fluids (Thermodynamics, Fluid Mechanics, and Heat Transfer), Springer-Verlag Berlin Heidelberg, Germany, pp. 601606 (2005).
  13. [13] Ghiaasiaan, S. M., Two Phase Flow, Boiling and Condensation (In Conventional and Miniature Systems), Cambridge University Press, UK, pp. 121136 (2008). doi: 10.1017/CBO9780511619410.003
  14. [14] Tong, L. S. and Tang, Y. S., Boiling Heat Transfer and Two-Phase Flow, 2nd ed., Taylor and Francis, USA, pp. 119147 (1997).
  15. [15] Kandlikar, S. G., Shoji, M. and Dhir, V. K., Handbook of Phase Change: Boiling and Condensation, Taylor and Francis, USA, pp. 205218 (1999).
  16. [16] Theilacker, J. C. and Rode, C. H., “An Investigation into Flow Regimes for Two-Phase Helium Flow,” A Cryogenic Engineering Conference Publication, Springer US., Vol. 33, pp. 391398 (1987). doi: 10.1007/ 978-1-4613-9874-5_48
  17. [17] Ghajar, A. J. and Tang, C. C., “Void Fraction and Flow Patterns of Two-Phase Flow in Upward and Downward Vertical and Horizontal Pipes,” Advances in Multiphase Flow and Heat Transfer, Vol. 4, pp. 175201 (2012). doi: 10.2174/978160805229511204 010175
  18. [18] Wongwises, S. and Pipathattakul, M., “Flow Pattern, Pressure Drop and Void Fraction of Two-Phase Flow Gas-Liquid in an Inclined Narrow Annular Channel,” Experimental Thermal and Fluid Science, Vol. 30, No. 4, pp. 345354 (2006). doi: 10.1016/j.expthermflusci. 2005.08.002
  19. [19] Azzopardi, B. J., Chemical Engineering and Chemical Process Technology, Multiphase Flow, Vol. 1, EOLSS Publishers, UK, pp. 97130 (2010).
  20. [20] Mandhane, J. M., Gregory, G. A. and Aziz, K., “A Flow Pattern Map for Gas-Liquid Flow in Horizontal Pipes,” International Journal of Multiphase Flow, Vol. 1, No. 4, pp. 537553 (1974). doi: 10.1016/0301-9322 (74)90006-8
  21. [21] Baker, O., “Design of Pipe Lines for Simultaneous Flow of Oil and Gas,” Oil and Gas Journal, Vol. 53, No. 12, pp. 185195 (1954).
  22. [22] Stephanie, B., A Beginner’s Guide to Uncertainty of Measurement (Issue 2), National Physical Laboratory, UK, pp. 226 (2001).
  23. [23] Moffat, R. J., “Describing the Uncertainties in Experimental Results,” Experimental Thermal and Fluid Science, Vol. 1, No. 1, pp. 317 (1988). doi: 10.1016/ 0894-1777(88)90043-X
  24. [24] Ueda, T., Two-Phase Flow (in Japanese), Yokendo Co, Ltd, (1989).